沼氣工程設備的定時保護保養是發揮沼氣工程效益的重要環節。有些沼氣工程建成后，由于保護辦理不當，形成沼氣工程不能運轉，因而應當加強設備的保護和保養。
Regular protection and maintenance of biogas engineering equipment is an important link to give full play to the benefits of biogas engineering. After the completion of some biogas projects, due to improper protection, the biogas projects cannot operate. Therefore, the protection and maintenance of equipment should be strengthened.
（1）格柵
(1) Grating
應定時檢修、保養格柵，關于破損的要及時替換。機械格柵機運轉結束后應及時清洗格柵機。
The grating shall be repaired and maintained regularly, and the damaged ones shall be replaced in time. After the operation of the mechanical grating machine is completed, the grating machine shall be cleaned in time.
（2）泵房
(2) Pump house
①在每次停泵后，應查看填料或油封處的密封情況，進行的處理，并根據需要增加或替換填料、潤滑油、潤滑脂。
① After stopping the pump every time, check the sealing condition of the packing or oil seal, deal with it, and add or replace the packing, lubricating oil and grease as needed.
②應至少半年查看、調整、替換水泵進出水閘閥與填料1次。
② Check, adjust and replace the inlet and outlet sluice valves and packing of the water pump at least once every six months.
③應定時檢修集水池水標尺或液位計及其轉換設備。
③ The water gauge or liquid level gauge of the sump and its conversion equipment shall be overhauled regularly.
④備用泵應每月至少進行1次試運轉。環境溫度低于0℃時，放掉泵殼內的存水。
④ The standby pump shall be commissioned at least once a month. When the ambient temperature is lower than 0 ℃, drain the water stored in the pump casing.
（4）厭氧反應器
(4) Anaerobic reactor
①厭氧反應器的塔體、各種管道及閘閥應每年進行1次查看和修理。
① The tower body, various pipelines and gate valves of anaerobic reactor shall be inspected and repaired once a year.
②厭氧反應器的各種加熱設備應常常除垢。
② Various heating equipment of anaerobic reactor should often be descaled.
③當選用熱交換器加熱時，管道和閘閥處的密封材料應每年替換。
③ When the heat exchanger is selected for heating, the sealing materials at the pipeline and gate valve shall be replaced every year.
④當選用螺旋槳等機械拌和時，軸承應定時查看，增加潤滑油，支承架的銜接螺栓應常常查看和緊固。
④ When mechanical mixing such as propeller is selected, the bearing shall be checked regularly to add lubricating oil, and the connecting bolts of the support frame shall be checked and tightened frequently.
⑤蒸氣管道、沼氣管道的冷凝水應按規劃規則定時排放。
⑤ The condensate of steam pipeline and biogas pipeline shall be discharged regularly according to the planning rules.
⑥冰冷區域冬天，對溢流管、防爆設備的水封應做好設備和管道保溫防凍作業。
⑥ In winter in cold areas, the water seals of overflow pipes and explosion-proof equipment shall be well insulated and antifreezed.
⑦厭氧反應器運轉3~5年整理、檢修1次。
⑦ The anaerobic reactor shall be sorted and overhauled once every 3 ~ 5 years.
（5）沼氣貯氣柜
(5) Biogas gas holder
①定時查看沼氣貯氣柜、沼氣管道及閘閥是否漏氣。
① Regularly check whether the biogas storage tank, biogas pipeline and gate valve leak.
②沼氣貯氣柜表面的油漆或涂料應定時從頭涂飾。
② The paint or coating on the surface of biogas gas storage tank shall be painted from scratch regularly.
③沼氣貯氣柜的升降設施包括進出氣閥應常常查看，增加潤滑油（脂）。
③ The lifting facilities of biogas gas storage tank, including inlet and outlet valves, should be checked frequently to add lubricating oil (grease).
④冰冷季節前應檢修沼氣貯氣柜水封的防凍設施。
④ Before the cold season, the anti freezing facilities of the water seal of the biogas gas storage tank shall be overhauled.
⑤貯氣柜的儲存水每半年替換1次。
⑤ The water stored in the gas holder shall be replaced once every six months.
⑥沼氣貯氣柜運轉3~5年應修理1次，氣閥，使用壽命到期強制更新。
⑥ The biogas gas holder shall be repaired once every 3 ~ 5 years, and the gas valve shall be forcibly renewed when its service life expires.
⑦沼氣報警設備應每年檢修1次。
⑦ The biogas alarm equipment shall be overhauled once a year.
（6）沼氣凈化設備
(6) Biogas purification equipment
①定時查看沼氣凈化系統的氣密性，每周對旁路閥門和備用脫硫塔的閥門進行開、閉運轉。
① Regularly check the air tightness of the biogas purification system, and open and close the bypass valve and the valve of the standby desulfurization tower every week.
②定時掃除沼氣凈化設備中的冷凝水。
② Regularly sweep the condensate in the biogas purification equipment.
③根據設備要求定時替換脫硫劑。
③ Replace desulfurizer regularly according to equipment requirements.
The above is a detailed introduction to the utilization of biogas. I hope it will be helpful to you If you have any questions, please contact us We will provide you with professional service http://m.kkfoot.com
魯公網安備37011202000764號號 網站地圖XMLTXT
企業二維碼
2022-04-18
